AD 95-08-01

[Federal Register Volume 60, Number 68 (Monday, April 10, 1995)]
[Rules and Regulations]
[Pages 17988-17990]
From the Federal Register Online via the Government Publishing Office [www.gpo.gov]
[FR Doc No: 95-8446]


-----------------------------------------------------------------------


DEPARTMENT OF TRANSPORTATION
14 CFR Part 39

[Docket No. 94-NM-169-AD; Amendment 39-9190; AD 95-08-01]


Airworthiness Directives; Jetstream Model 4101 Airplanes

AGENCY: Federal Aviation Administration, DOT.

ACTION: Final rule.

-----------------------------------------------------------------------

SUMMARY: This amendment adopts a new airworthiness directive (AD), 
applicable to certain Jetstream Model 4101 airplanes, that requires 
modification of the spoiler system. This amendment is prompted by 
reports of fatigue failures of the tee fittings of the spoiler bleed 
nipples. The actions specified by this AD are intended to ensure that 
the tee fittings do not fail, and subsequently lead to loss of the main 
system hydraulics.

DATES: Effective May 10, 1995.
    The incorporation by reference of certain publications listed in 
the regulations is approved by the Director of the Federal Register as 
of May 10, 1995.

ADDRESSES: The service information referenced in this AD may be 
obtained from Jetstream Aircraft, Inc., P.O. Box 16029, Dulles 
International Airport, Washington, DC 20041-6029. This information may 
be examined at the Federal Aviation Administration (FAA), Transport 
Airplane Directorate, Rules Docket, 1601 Lind Avenue, SW., Renton, 
Washington; or at the Office of the Federal Register, 800 North Capitol 
Street, NW., suite 700, Washington, DC.

FOR FURTHER INFORMATION CONTACT: Sam Grober, Aerospace Engineer, 
Standardization Branch, ANM-113, FAA, Transport Airplane Directorate, 
1601 Lind Avenue, SW., Renton, Washington 98055-4056; telephone (206) 
227-1187; fax (206) 227-1320. [[Page 17989]] 
SUPPLEMENTARY INFORMATION: A proposal to amend part 39 of the Federal 
Aviation Regulations (14 CFR part 39) to include an airworthiness 
directive (AD) that is applicable to certain Jetstream Model 4101 
airplanes was published in the Federal Register on December 16, 1994 
(59 FR 64873). That action proposed to require modification of the 
spoiler system.
    Interested persons have been afforded an opportunity to participate 
in the making of this amendment. No comments were submitted in response 
to the proposal or the FAA's determination of the cost to the public.
    After careful review of the available data, the FAA has determined 
that air safety and the public interest require the adoption of the 
rule as proposed.
    The FAA estimates that 14 airplanes of U.S. registry will be 
affected by this AD, that it will take approximately 7 work hours per 
airplane to accomplish the required actions, and that the average labor 
rate is $60 per work hour. Required parts will be supplied by the 
manufacturer at no cost to the operators. Based on these figures, the 
total cost impact of the AD on U.S. operators is estimated to be 
$5,880, or $420 per airplane.
    The total cost impact figure discussed above is based on 
assumptions that no operator has yet accomplished any of the 
requirements of this AD action, and that no operator would accomplish 
those actions in the future if this AD were not adopted.
    The regulations adopted herein will not have substantial direct 
effects on the States, on the relationship between the national 
government and the States, or on the distribution of power and 
responsibilities among the various levels of government. Therefore, in 
accordance with Executive Order 12612, it is determined that this final 
rule does not have sufficient federalism implications to warrant the 
preparation of a Federalism Assessment.
    For the reasons discussed above, I certify that this action (1) is 
not a ``significant regulatory action'' under Executive Order 12866; 
(2) is not a ``significant rule'' under DOT Regulatory Policies and 
Procedures (44 FR 11034, February 26, 1979); and (3) will not have a 
significant economic impact, positive or negative, on a substantial 
number of small entities under the criteria of the Regulatory 
Flexibility Act. A final evaluation has been prepared for this action 
and it is contained in the Rules Docket. A copy of it may be obtained 
from the Rules Docket at the location provided under the caption 
ADDRESSES.

List of Subjects in 14 CFR Part 39

    Air transportation, Aircraft, Aviation safety, Incorporation by 
reference, Safety.

Adoption of the Amendment

    Accordingly, pursuant to the authority delegated to me by the 
Administrator, the Federal Aviation Administration amends part 39 of 
the Federal Aviation Regulations (14 CFR part 39) as follows:

PART 39--AIRWORTHINESS DIRECTIVES

    1. The authority citation for part 39 continues to read as follows:

    Authority: 49 U.S.C. App. 1354(a), 1421 and 1423; 49 U.S.C. 
106(g); and 14 CFR 11.89.


Sec. 39.13  [Amended]

    2. Section 39.13 is amended by adding the following new 
airworthiness directive:

95-08-01  Jetstream Aircraft Limited: Amendment 39-9190. Docket 94-
NM-169-AD.

    Applicability: Model 4101 airplanes on which Jetstream 
Modification JM41290B (reference Jetstream Service Bulletin J41-29-
001) has not been installed, certificated in any category.

    Note 1: This AD applies to each airplane identified in the 
preceding applicability provision, regardless of whether it has been 
modified, altered, or repaired in the area subject to the 
requirements of this AD. For airplanes that have been modified, 
altered, or repaired so that the performance of the requirements of 
this AD is affected, the owner/operator must use the authority 
provided in paragraph (b) to request approval from the FAA. This 
approval may address either no action, if the current configuration 
eliminates the unsafe condition; or different actions necessary to 
address the unsafe condition described in this AD. Such a request 
should include an assessment of the effect of the changed 
configuration on the unsafe condition addressed by this AD. In no 
case does the presence of any modification, alteration, or repair 
remove any airplane from the applicability of this AD.
    Compliance: Required as indicated, unless accomplished 
previously.
    To prevent failure of the tee fittings and subsequent loss of 
the main system hydraulics, accomplish the following:
    (a) Within 4 months after the effective date of this AD, modify 
the spoiler system in accordance with Jetstream Service Bulletin 
J41-29-001, dated August 12, 1994, or Revision 1, dated August 30, 
1994.
    (b) An alternative method of compliance or adjustment of the 
compliance time that provides an acceptable level of safety may be 
used if approved by the Manager, Standardization Branch, FAA, 
Transport Airplane Directorate, ANM-113. Operators shall submit 
their requests through an appropriate FAA Principal Maintenance 
Inspector, who may add comments and then send it to the Manager, 
Standardization Branch, ANM-113.

    Note 2: Information concerning the existence of approved 
alternative methods of compliance with this AD, if any, may be 
obtained from the Standardization Branch, ANM-113.

    (c) Special flight permits may be issued in accordance with 
sections 21.197 and 21.199 of the Federal Aviation Regulations (14 
CFR 21.197 and 21.199) to operate the airplane to a location where 
the requirements of this AD can be accomplished.
    (d) The modification shall be done in accordance with the 
following Jetstream service bulletins, as applicable, which contain 
the specified effective pages:

------------------------------------------------------------------------
  Service bulletin                 Revision level                       
referenced and date    Page No.     shown on page    Date shown on page 
------------------------------------------------------------------------
J41-29-001 Original         1-12  Original........  Aug. 12, 1994.      
 Issue, August 12,                                                      
 1994.                                                                  
J41-29-001 Revision         1, 3  1...............  Aug. 30, 1994.      
 1, August 30, 1994.                                                    
                         2, 4-12  Original........  Aug. 12, 1994.      
------------------------------------------------------------------------

[[Page 17990]] This incorporation by reference was approved by the 
Director of the Federal Register in accordance with 5 U.S.C. 552(a) 
and 1 CFR part 51. Copies may be obtained from Jetstream Aircraft, 
Inc., P.O. Box 16029, Dulles International Airport, Washington, DC 
20041-6029. Copies may be inspected at the FAA, Transport Airplane 
Directorate, 1601 Lind Avenue, SW., Renton, Washington; or at the 
Office of the Federal Register, 800 North Capitol Street, NW., suite 
700, Washington, DC.
    (e) This amendment becomes effective on May 10, 1995.

    Issued in Renton, Washington, on March 31, 1995.
Darrell M. Pederson,
Acting Manager, Transport Airplane Directorate, Aircraft Certification 
Service.
[FR Doc. 95-8446 Filed 4-7-95; 8:45 am]
BILLING CODE 4910-13-U